发酵罐灭菌之后，就可以用来培养细菌了。接上pH电极的插头,接通底部冷却水管和空气出口处的冷凝器上的冷却水管,将各硅酮管置于相应的蠕动泵上。把搅拌马达置于搅抖联动装置上。把光标调到“Temperature”档,设定一个合适的温度。校正溶氧电极的满刻度。利用光标将搅拌速度调至大转速，一般为800r/min,把通气量调节到1.0LAir/Lmedium/min(1VVM)。调到calibration界面，光标调至溶氧处，“span”档,设定读数为100，反复调节几次，直至稳定至100，转至menu界面。其他参数设定。把光标调到Agit档，设定小值为200r/min。把光标调到DO档,设定参数为合适的值,调整为与溶氧偶联检测。把光标调到Agit档，设定大值为800r/min;把光标调到pH档,设定参数为7.0，调整为自动检测;接上酸(碱)瓶，并打开自动检测系统。浙江昊普流体设备有限公司致力于发酵罐，有想法的可以来电咨询！安徽液体发酵罐定制

发酵罐控制器的操作：控制器的启动：打开电源，先按一下薄膜键盘上的“S/E”键，再按一下“确认”键，发酵控制程序启动；这时，如果加热器中水没有加满，程序会自动进行进水操作；待水加满后，用户可以按照上述的下位机控制器的操作方法进行对各个执行机构进行控制。控制器的操作：使用F1～F6按键将液晶屏中的界面切换到用户需要控制的界面中，使用方向键将界面中的光标移动到需要控制的变量上，如果是改变运行模式，直接按确认键即可，如果需要键盘输入数字，在输入数字后按确认键即可。安徽液体发酵罐定制发酵罐，就选浙江昊普流体设备有限公司，欢迎客户来电！

发酵罐使用注意事项：在空消、实消结束后冷却过程中，严禁发酵罐内产生负压，以免造成污染，甚至损坏设备。在发酵过程中，发酵罐的罐压应维持在0.03～0.05MPa之间，以免引起污染。在各操作过程中，必须保持空气管道中的压力大于发酵罐的罐压，否则会引起发酵罐中的液体倒流进入过滤器中，堵塞过滤器滤芯或使过滤器失效。如果遇到自己解决不了的问题请直接与发酵罐的售后服务部门联系。请勿强行拆卸或维修发酵罐。在消毒过滤器时，流经空气过滤器的蒸汽压力不得超过0.17MPa，否则过滤器滤芯会被损坏，失去过滤能力。在空消及实消时，一定要排尽发酵罐夹套内的余水。否则可能会导致发酵罐内筒体压扁，造成设备损坏;在实消时，还会造成冷凝水过多导致培养液被稀释，从而无法达到工艺要求。

发酵罐的维护有：发酵罐精密过滤器，一般使用期限为半年。如果过滤阻力太大或失去过滤能力致影响正常生产，则需清洗或更换(建议直接更换，不作清洗，因清洗操作后不能可靠保证过滤器的性能)。清洗发酵罐时，请用软毛刷进行刷洗，不要用硬器刮擦，以免损伤发酵罐表面。发酵罐配套仪表应每年校验一次，以确保正常使用。发酵罐的电器、仪表、传感器等电气设备严禁直接与水、汽接触，防止受潮。发酵罐停止使用时，应及时清洗干净，排尽发酵罐及各管道中的余水;松开发酵罐罐盖及手孔螺丝，防止密封圈产生长久变形。浙江昊普流体设备有限公司为您提供发酵罐，欢迎您的来电！

食品发酵类型众多，若不加以控制，就会导致食品腐烂变质。控制食品发酵过程的主要因素有酸度、酒精含量、菌种的使用、温度、通氧量和加盐量等。这些因素同时还决定着发酵食品后期贮藏中的微生物生长的类型。复杂的有机化合物在微生物的作用下分解成比较简单的物质。发面、酿酒等都是发酵的应用。也作酦酵。汉词“发酵”作为名词表示一个过程，作为动词表示一种行动。微生物生理学严格定义的“发酵”：有机物被生物体氧化降解成氧化产物并释放能量的过程统称为生物氧化。微生物生理学把生物氧化区分为呼吸和发酵，呼吸又可进一步区分为有氧呼吸和无氧呼吸。因此，发酵是生物氧化的一种方式。浙江昊普流体设备有限公司致力于发酵罐，欢迎您的来电！安徽液体发酵罐定制

发酵罐，就选浙江昊普流体设备有限公司，有需要可以联系我司哦！安徽液体发酵罐定制

发酵罐的结构特性：可在线CIP清洗、SIP灭菌(121°C/0.1MPa)。按照卫生级要求设计，结构设计极具人性化，操作方便。传动平稳，噪音低。适宜的径高比设计，按需定制搅拌装置，节能，搅拌、发酵效果好。内罐体表面镜面抛光处理(粗糙度Ra≤0.4µm)；各进出管口、视镜、人孔等工艺开孔与内罐体焊接处均采用拉伸翻边工艺圆弧过渡，光滑易清洗无死角，保证生产过程的可靠性、稳定性，符合“cGMP”等规范要求。食醋自吸式发酵罐罐体：主要用来培养发酵各种菌体，密封性要好（防止菌体被污染）。安徽液体发酵罐定制

本文来自海润达物联科技有限责任公司：//qfd1mz.cn/Article/35a06099904.html